Monday, May 14, 2018

DentaPure Water Filtration System

About 4 years ago, I was fortunate enough to be contacted by the DentaPure folks to evaluate their water filtration system.  The system is simple, efficient, and quite literally applies “rocket science” to the problem of dental unit waterlines.
Those of us in clinical practice know how important clean water lines are.  The tiny diameter of dental unit waterlines (DUW)  allow for the growth of bacteria within them.  These bacteria have the potential to cause infection to patients.  This can occur when a highspeed handpiece is spraying coolant water into a surgical site.  Spraying contaminated coolant spray has the potential to inoculate the area with the DWU bacteria.  To prevent this potential, the Centers for Disease Control (CDC) recommend some type of process to prevent the bacterial growth.
There have been several ideas toward achieving the goal of low bacterial counts, but most were complicated and labor intensive.  As we all know, the simpler a system is, the more likely it is to be used and the better it works.  That’s where DentaPure comes in.
The system was developed to clean contaminated water on the space shuttle and the International Space Station (ISS).  Since water in outer space is a valuable commodity and expensive to provide, NASA needed to develop a way to send as little water as possible into space.  The result was a filtration system that allowed astronauts to take a small amount of water and continually purify it for reuse.  The resultant system was then cleared for use in the private sector, including healthcare.
In my office, the blue filter in the picture at the top of this post, is installed inside the water bottle in each operatory.  In order to decrease the chance of contamination, all seven of our treatment rooms are NOT connected to the municipal water supply.  Instead, each dental unit has water supplied by a 1 liter bottle that is filled daily from our in office water distiller.  The distillation process removes hard chemical deposits which keeps the water lines free from hard water buildup, but does not affect bacteria.  To prevent bacterial contamination, the water is filtered through the DentaPure cartridge prior to entering the dental unit.  The cartridge is actually installed inside the unit water bottle and purifies the water before it enters the system.  The cartridge lasts for 365 days and requires no maintenance other than being replaced once per year.
As readers of the blog know, I got a chance on April 2nd to visit the Kennedy Space Center to witness a SpaceX launch up close and personal.  I’ve always been a HUGE fan of NASA and part of the reason for that is the incredible amount of science that is created by them that trickles down to the rest of society.  When someone says to me “why are we spending all of this money with NASA?” I reply with a list of some of the things we use everyday that was developed by them.  DentaPure is one of those products.
Here is the story of DentaPure from the NASA Spinoff website.

Water, essential to sustaining life on Earth, is that much more highly prized in the unforgiving realm of space travel and habitation. Given a launch cost of $10,000 per pound for space shuttle cargo, however, each gallon of water at 8.33 pounds quickly makes Chanel No. 5 a bargain at $25,000 per gallon. Likewise, ample water reserves for drinking, food preparation, and bathing would take up an inordinate amount of storage space and infrastructure, which is always at a premium on a vessel or station.

The DentaPure waterline purification cartridge sees use in 40 percent of dental schools in the United States and is lauded for offering remarkable filtration and significant cost savings.
Water rationing and recycling are thus an essential part of daily life and operations on the space shuttles and International Space Station (ISS). In orbit, where Earth’s natural life support system is missing, the ISS itself has to provide abundant power, clean water, and breathable air at the right temperature and humidity for the duration of human habitation and with virtually no waste. The Environmental Control and Life Support System (ECLSS), under continuing developmet at the Marshall Space Flight Center, helps astronauts use and reuse their precious supplies of water. Future work will explore air management, thermal control, and fire suppression—in short, all of the things that will make human habitation in space comfortable and safe.

The ECLSS Water Recycling System (WRS), developed at Marshall, reclaims wastewaters from humans and lab animals in the form of breath condensate, urine, hygiene and washing, and other wastewater streams. On Earth, biological wastewater is physically filtered by granular soil and purified as microbes in the soil break down urea, converting it to a form that plants can absorb and use to build new tissue. Wastewater also evaporates and returns as fresh rain water—a natural form of distillation. WRS water purification machines on the ISS mimic these processes, though without microbes or the scale of these processes.


Umpqua Research Company, of Myrtle Creek, Oregon, supplier of the bacterial filters used in the life support backpacks worn by space-walking astronauts, received a number of Small Business Innovation Research (SBIR) contracts from the Johnson Space Center to develop air and water purification technologies for human missions in space. A natural choice for water purification research, Umpqua has also provided the only space-certified and approved-for-flight water purification system, which has flown on all shuttle missions since 1990.

To prevent back-contamination of a drinking water supply by microorganisms, Umpqua developed the microbial check valve, consisting of a flow-through cartridge containing iodinated ion exchange resin. In addition to the microbial contact kill, the resin was found to impart a biocidal residual elemental iodine concentration to the water. Umpqua’s valve and resin system was adopted by NASA as the preferred means of disinfecting drinking water aboard U.S. spacecraft, and canisters are now used on space shuttle missions, the ISS, and for ground-based testing of closed life support technology. Iodine was selected by NASA as the disinfectant of choice because of its lower vapor pressure and reduced propensity for formation of disinfection byproducts compared to chlorine or bromine.

Product Outcome

Long service intervals of up to a year and ease of installation make the DentaPure cartridge particularly user-friendly.
MRLB International Inc., of Fergus Falls, Minnesota, used Umpqua’s water purification technology in the design of the DentaPure waterline purification cartridge (Spinoff 1998). The cartridge incorporated a resin technology developed by private sector commercialization of Umpqua’s system developed under NASA contract. NASA “was an excellent resource,” stated Barry Hammarback, president and CEO of MRLB, “and greatly assisted our transition of the iodinated resin technology to the dental industry.” DentaPure was designed to clean and decontaminate water as a link between filter and high-speed dental tools and other instruments, and offers easy installation on all modern dental unit waterlines with weekly replacement cycles. The product, like its NASA forebear, furnished disinfected water and maintained water purity even with “suckback,” an effect caused by imperfect anti-retraction valves in dental instruments, which draws blood, saliva, and other materials from a patient’s mouth into the waterline.

Since its appearance in Spinoff 1998, MRLB has continued to use the research conducted by Umpqua to further develop and refine its DentaPure in-line filters. Various models now address a variety of needs, and are used in dental offices and schools across the country. MRLB has paid particular attention to extending the life in lower water usage units—products that before touted a service/replacement interval of 7 days now require changing once every 40 to 365 days. In addition, DentaPure offers remarkable filtration: registered to provide 200 CFU/ml purity (Colony Forming Unit/milliliter, a standard measure of microbial concentration)—the Centers for Disease Control and Prevention (CDC) standard is 500 CFU, and untreated lines can harbor in excess of 1,000,000 CFU/ml.

Continued evolution and improvement has led to many unique certifications and commendations for DentaPure. Currently, the only waterline system recognized by the U.S. Food and Drug Administration (FDA) as a medical device which meets all known standards, and by the U.S. Environmental Protection Agency (EPA) as an antimicrobial device, DentaPure has also been tested and utilized by the U.S. Air Force and dental schools in the United States and Europe, and was recognized by Clinical Research Associates as “Outstanding Product 2005.”

Better filtration, greater capacity, and longer service intervals have also led to great savings—the University of Maryland Dental School estimates it saves $274,000 per year courtesy of DentaPure. The DentaPure system has proven so effective that 40 percent of dental schools nationwide employ it. Dr. Louis DePaola of the University of Maryland affirms, “The biggest benefit is that we have a system that is efficacious and user-friendly, in that it allows us to consistently deliver water that meets or exceeds CDC standards with a minimum of staff interaction—attach the unit and except for periodic monitoring you don’t have to do anything for a year. It’s very cost-effective—for a large institution like ours with an excess of 300 units, a daily or weekly treatment isnot practical.”

DentaPure is currently the number one product for constant chemical treatment applications in dentistry, and was the first treatment to meet CFU standards without interim cleaning protocols—the primary means by which it saves money. Turning to the future, Hammarback sees DentaPure “looking at remote site water purification for continuous use, providing yet longer lasting devices, and increasing product recycling.” Ten years after Spinoff first profiled the many benefits of this technology it is utilized every day in myriad dental offices, schools, and labs, saving hundreds of thousands of dollars a year for users such as the University of Maryland. The investment in water filtration for space missions continues to pay huge dividends to users and society, year after year, in technologies so woven into our lives that we use them without even thinking about them.

DentaPure® is a registered trademark of MRLB International Inc.


  1. Informative blog post, DentaPure literally uses rocket science developed for NASA to provide clean dental unit waterlines. The technology developed for NASA was used to ensure water consumed in space is free of bacteria, viruses and any other harmful organisms. It is one of the best Dental Lab System that can improve the effenciny of your lab.

  2. Very nice post! Water filtration system is required to get water impurities removed so that one can safely drink water. It is good to know that that kind of water filtration is available to everyone. Thank you very much for sharing updates regarding this. I would like to see more information in this.
    Water filtration systems Monroe